Pozdrav!
Imam vw touran 1.9, 77kw, bkc motor, 2005. godiste.
Pre 10-ak dana se prvi put desilo da sam imao problem sa paljenjem auta, tj u popodnevnim satima kada sam probao da ga upalim auto samo vergla, ali je cudan zvuk verglanja, kao da se gusi i nece da upali, a primetio sam da kada nece da se upali da tada ne zazuji pumpa prilikom davanja kontakta. Onda vise puta pukusam da upalim i da samo dajem kontakt i da ga iskljucujem i u jednom momentu se cuje zujanje pumpe posle davanja kontakta i tada upali auto. Kada upalim auto, rad motora je ravnomeran i u voznji se lepo ponasa i vuce lepo.
Problem sa paljenjem nikad nisam imao u jutarnjim satima pri prvom paljenju. Problem pri paljenju se najcesce desava u toku dana kada pokusam da upalim auto.
Imao sam pre par dana kod sebe vcds dijagnostiku i ocitao sam sledece greske i snimio log.
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 1T (1K0)
Scan: 01 03 08 09 15 16 17 18 19 25 42 44 46 52 56 62 72
VIN: ------------ Mileage: 258050km-160344miles
00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 1010
03-ABS Brakes -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
18-Aux. Heat -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: Malfunction 1010
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine Labels: 03G-906-016-BKC.clb
Part No SW: 03G 906 016 CD HW: 028 101 194 5
Component: R4 1,9L EDC G000SG 6246
Revision: 12345678 Serial number: VWZ7Z0E3024218
Coding: 0000072
Shop #: WSC 01324 785 00200
VCID: 67DD0E9B566DDDBEAA-8032
2 Faults Found:
18049 - Please check DTC Memory of A/C Controller
P1641 - 000 - - Intermittent
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 12.24 V
Bin. Bits: 00001100
Temperature: 61.2°C
(no units): 144.0
19781 - Power Supply Terminal 15
P3325 - 000 - Implausible - Intermittent
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 12.84 V
Bin. Bits: 00001100
Bin. Bits: 0
(no units): 1.0
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No SW: 1K0 907 379 AA HW: 1K0 907 379 AA
Component: ESP FRONT MK60 0102
Revision: 00H13001
Coding: 0021190
Shop #: WSC 01324 785 00200
VCID: 71E960C368A9130EF4-8024
1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-907-044.lbl
Part No: 1K0 907 044 BE
Component: ClimatronicPQ35 090 0808
Shop #: WSC 00000 000 00000
VCID: 6BD572AB4A85F9DECE-803E
2 Faults Found:
01274 - Air Flow Flap Positioning Motor (V71)
000 - -
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels:. 3C0-937-049-23-M.lbl
Part No SW: 3C0 937 049 D HW: 3C0 937 049 D
Component: Bordnetz-SG H37 1002
Revision: 00H37000 Serial number: 00000005166897
Coding: 008B8F210004100000120C000000000000097B075C
Shop #: WSC 80093 222 69422
VCID: 2A5BB7AF85FF20D675-807E
Subsystem 1 - Part No: 1T0 955 119 C Labels: 1KX-955-119.CLB
Component: Wischer VW358 012 0401
Coding: 00065493
Shop #: WSC 80093
1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00110100
Fault Priority: 2
Fault Frequency: 7
Reset counter: 153
Mileage: 257920 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 12.35 V
ON
ON
OFF
OFF
OFF
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1T0-909-605.lbl
Part No SW: 1T0 909 605 C HW: 1T0 909 605 C
Component: 02 AIRBAG VW62 0506 1500
Revision: 09025000 Serial number: 0038BD0G4JWK
Coding: 0012338
Shop #: WSC 01324 785 00200
VCID: 356194D35C417F2EE8-8060
2 Faults Found:
01228 - Airbag Cut-Off Switch for Passenger Side (E224)
008 - Implausible Signal - Intermittent - MIL ON
01218 - Side Airbag Igniter; Passenger Side (N200)
001 - Upper Limit Exceeded - Intermittent - MIL ON
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY8.lbl
Part No SW: 1K0 953 549 AF HW: 1K0 953 549 AF
Component: Lenksäulenmodul 034 0070
Coding: 0000042
Shop #: WSC 01324 785 00200
VCID: 76E353DF01C7343621-8022
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No: 1T0 920 862 F
Component: KOMBIINSTRUMENT VDD 4312
Coding: 0007101
Shop #: WSC 80093 222 69422
VCID: 366393DF41477436E1-8062
3 Faults Found:
00771 - Fuel Level Sensor (G)
003 - Mechanical Failure - Intermittent
00771 - Fuel Level Sensor (G)
010 - Open or Short to Plus - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 18: Aux. Heat Labels: 1K0-815-071.clb
Part No: 1K0 815 071 P
Component: Zuheizer 031 1312
Revision: A Serial number: 09010046
Coding: 0000011
Shop #: WSC 01324 785 00200
VCID: 326BAFCFAD2F6816CD-8066
5 Faults Found:
01415 - Recirculating Pump (V55)
010 - Open or Short to Plus - Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 0
Fault Frequency: 255
Reset counter: 60
Mileage: 254425 km
Time Indication: 0
Date: 2000.00.00
Time: 22:54:09
Freeze Frame:
OFF
Temperature: 27.0°C
Temperature: 31.0°C
02085 - Incorrect Control Module Installed
000 - - - Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 0
Fault Frequency: 255
Reset counter: 60
Mileage: 254425 km
Time Indication: 0
Date: 2000.00.00
Time: 22:54:09
00664 - Fuel gauge
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 0
Fault Frequency: 52
Reset counter: 187
Mileage: 260917 km
Time Indication: 0
Date: 2000.00.00
Time: 28:53:41
01444 - Under-Voltage Shut-Off (Automatic)
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 0
Fault Frequency: 52
Reset counter: 187
Mileage: 260917 km
Time Indication: 0
Date: 2000.00.00
Time: 28:53:41
01415 - Recirculating Pump (V55)
007 - Short to Ground - Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 0
Fault Frequency: 255
Reset counter: 60
Mileage: 254425 km
Time Indication: 0
Date: 2000.00.00
Time: 22:54:09
Freeze Frame:
OFF
Temperature: 27.0°C
Temperature: 31.0°C
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V1.clb
Part No SW: 1K0 907 530 F HW: 1K0 907 951
Component: Gateway H10 0120
Revision: H10 Serial number: 2800105B19054C
Coding: 3D3F1340078002
Shop #: WSC 01324 785 00200
VCID: 2A5BB7AF85FF20D675-807E
2 Faults Found:
01304 - Radio
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 254
Reset counter: 156
Mileage: 242033 km
Time Indication: 0
Date: 2000.00.00
Time: 15:48:02
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 33
Reset counter: 155
Mileage: 257507 km
Time Indication: 0
Date: 2000.00.00
Time: 14:15:26
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No: 1T0 920 862 F
Component: IMMO VDD 4312
Shop #: WSC 00000 000 00000
VCID: 366393DF41477436E1-8062
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MIN2.lbl
Part No: 1T0 959 701 B
Component: Tuer-SG 024 2301
Coding: 0000180
Shop #: WSC 01324 785 00200
VCID: 366393DF41477436E1-8062
2 Faults Found:
01552 - Motor for Central Locking; Drivers Door (V56); Lock
012 - Electrical Fault in Circuit - Intermittent
00928 - Locking Module for Central Locking; Front Driver Side (F220)
008 - Implausible Signal - Intermittent
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-144-G2V2.clb
Part No: 1K1 909 144 K
Component: EPS_ZFLS Kl.5 D06 1701
Shop #: WSC 00000 000 00000
VCID: 3365AACB5235611EC6-8066
1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
Freeze Frame:
Mileage: 7480 km
Temperature: 27.0°C
Voltage: 12.40 V
Voltage: 12.20 V
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 1K0-959-433-MIN.clb
Part No: 1K0 959 433 AK
Component: KSG 0401
Coding: 00C802087F2D8405484F016010CC
Shop #: WSC 01324 785 00200
VCID: 79F958E330D95B4E4C-802C
Subsystem 1 - Component: Sounder n.mounted
Subsystem 2 - Component: NGS n.mounted
Subsystem 3 - Component: IRUE n.mounted
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MIN2.lbl
Part No: 1T0 959 702 B
Component: Tuer-SG 024 2301
Coding: 0000180
Shop #: WSC 01324 785 00200
VCID: 377D9EDB464D8D3EFA-8062
2 Faults Found:
00097 - Front Passengers Central Locking (Safe) Motor (V162)
012 - Electrical Fault in Circuit
00929 - Locking Module for Central Locking; Front Passenger Side (F221)
008 - Implausible Signal
-------------------------------------------------------------------------------
Address 56: Radio
Cannot be reached
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 1K0-959-703-GEN1.lbl
Part No: 1K0 959 703 B
Component: Tuersteuergeraet 06 0214
Coding: 0000048
Shop #: WSC 01324 785 00200
VCID: 2F6DA6BBBE1D45FEA2-807A
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 1K0-959-704-GEN1.lbl
Part No: 1K0 959 704 B
Component: Tuersteuergeraet 06 0214
Coding: 0000048
Shop #: WSC 01324 785 00200
VCID: 306FA5C7A3235A06BB-8064
No fault code found.
End-------------------------(Elapsed Time: 01:38)--------------------------
